Peugeot405
1. The maintenance instruction
2. Maintenance service
2.1. A technical characteristics
2.2. Periodicity of service
2.3. Each 7 500 km
2.4. Each 10 000 km or 6 months
2.5. Each 20 000 km or 12 months
2.5.1. The control of hoses of system of ventilation картера the engine
2.5.2. Replacement of the fuel filter
2.5.3. Check of turns of idling and structure of a mix (WITH)
2.5.4. Replacement of spark plugs
2.5.5. Check, adjustment and coupling greasing
2.5.6. Check of a condition of a protective cover of a power shaft
2.5.7. Check of a condition forward and back brake pads
2.5.8. Check and adjustment of a manual brake
2.5.9. Check of a condition of a suspension bracket
2.5.10. Check of drainage apertures
2.6. Each 30 000 km or 18 months
2.7. Each 40 000 km or 2 years
2.8. Each 60 000 km or 3 years
3. Engines
4. Fuel system
5. Systems of greasing, cooling
6. Release system
7. Coupling
8. Transmissions
9. Power shafts
10. A steering
11. Suspension brackets
12. Brake system
13. A body
14. An electric equipment
|
PETROL ENGINES
The prevention At performance of works on fuel system it is necessary to observe extra care.
Replacement of the fuel filter is made through 30 000 km for carburettor models and 60 000 km for models with injection. Carburettor models
|
|
The fuel filter is established in a hose of giving of fuel between the pump and the carburettor in a motor compartment. |
| PERFORMANCE ORDER |
| 1. For replacement of the fuel filter to remove collars from hoses, and then to remove hoses from the filter. |
| 2. At installation of the filter to pay attention to an arrow on the case of the filter which shows a direction of a stream of the fuel passing through the filter, that is to the fuel pump. |
3. To check up the fuel tank for a sediment of impurity and deposits from outside the carburettor. To clear the tank as required.
|
4. Unions of fuel system on the tank:
– The top hose – return to the tank;
– An average hose – from the pump;
– The bottom hose – to an entrance aperture of the carburettor. |
|
Models with system of injection of fuel
|
|
The fuel filter is located under the car bottom, on the right party of a fuel tank. By arrows hoses of giving of fuel (A) and fastening brackets (B) are shown. |
| PERFORMANCE ORDER |
| 1. To clamp a hose of giving of fuel from outside the filter, to remove collars from hoses, and then to remove hoses from the filter. To weaken a fastening nut brackets the filter and to extend the filter from brackets. |
| 2. At installation of the filter to pay attention to an arrow on the case of the filter which shows a direction of a stream of the fuel passing through the filter. |
| 3. To establish the new filter in bracket and to fix a nut, then to establish collars and to remove a clip from a fuel hose. |
| 4. To start the engine and to check up connections of hoses with the filter on tightness. |
|
DIESEL ENGINES
The filter it is necessary to replace each 22 500 km.
| PERFORMANCE ORDER |
| 1. To remove the bottom cover in a place of fastening of the filter. |
| 2. To replace filtrational вкладку and to check up a condition of linings. |
| 3. To fix a cover. |
| 4. To start the engine and to check up tightness. |
|
|
|